Safety Data Sheet for Chemical Products
according ISO 11014-1
Page 1 of 5
Date: 06-02-2015
06-02-2007
-2015
1
Product and company identification
1.1
Product name:
Delsorb-HQ-SB-R
Delsorb-HQ-SB-WS
1.2
Name + address supplier:
SPX Dehydration & Process Filtration B.V.
Munnikenheiweg 41
4879 NE ETTEN-LEUR
the Netherlands
1.3
Telephone number:
+31-76-5085800
1.4
Telefax number:
+31-76-5085590
Composition/information on ingredients
Chemical names and synonyms: Silica Gel
Ingredients considered hazardous to health:
Substance Name
Silica (7631-86-9)
Aluminium Oxide (1344-28-1)
Weight %
95-100
1-5
EU Classification
NA
NA
Notes: EC symbol(s): NA
See section 15 for European Label Information
3
Hazards identification
Effects of overexposure
Inhalation of dust particles may cause silicosis.
Eye contact
Skin contact
Inhalation
:
:
:
Ingestion
Flush thoroughly with water. If irritation occurs, call a doctor.
Wash contact areas with soap and water
Remove from further exposure. If respiratory irritation, dizziness,
nausea or unconsciousness occurs, seek medical assistance and call
an ambulance. If breathing has stopped, use mouth to mouth
resuscitation.
Not expected to be a problem. However, if greater than litre
(pint) is ingested or if feeling uncomfortable, give 1 to 2 glasses of
water and obtain medical attention or call an ambulance for
assistance. DO NOT INDUCE VOMITING or give anything by
mouth to an unconscious person.
First-aid measures
SF4301EN/C
Product names :
Delsorb-HQ-SB-R
Delsorb-HQ-SB-WS
Fire-fighting measures
Extinguishing media
Special fire fighting procedures
:
:
Special protective equipment
Unusual fire and explosion hazards
Flash point
Flammable limits
NFPA Hazard ID
Hazardous decomposition products
:
:
:
:
:
Page 2 of 5
Not applicable
This material will not burn, however, use standard chemical
fire-fighting procedures and consider the hazards of other
involved materials. Prevent run off from fire control or dilution
from entering waterways or drinking water supply.
For fires in enclosed areas, fire-fighters must use self-contained
breathing apparatus.
None
NA
LEL - NA; UEL - NA
Health: 0, Flammability: 0, Reactivity: 0
Silicon dioxide
Accidental release measures
Notification procedures
Report spills as required to appropriate authorities such as the
local Environmental Health Officer or Fire Brigade. If spills are
likely to enter any drain, waterway or groundwater, contact the
Area Authority. In case of accident or road spill, contact the
Police and Fire Brigade and, if appropriate, the Area Water
Authority.
Procedures if material is
released or spilled
Environmental precautions
Personal precautions
Shovel up and dispose of at an appropriate licensed waste
disposal site in accordance with current applicable laws and
regulations and product characteristics at time of disposal.
Prevent spills from entering storm sewers or drains and contact
with soil.
See section 8
Handling and storage
Handling
Storage
No special precautions are necessary beyond normal good
hygiene practices. See section 8 for additional personal
protection advice when handling this product.
Do not store in open or unlabelled containers. Store away from
strong oxidizing agents or combustible material.
SF4301EN/C
Product names :
Delsorb-HQ-SB-R
Delsorb-HQ-SB-WS
Page 3 of 5
Exposure controls/personal protection
Ventilation
Respiratory protection
:
:
Eye protection
Skin protection
:
:
Use in well ventilated area
Approved dust respirators must be used for dusty conditions
or if dust levels exceed exposure limits.
Normal industrial eye protection practices should be employed.
No special equipment required. However, good personal
hygiene practices should always be followed.
Exposure limits
Substance Name (CAS No.)
SILICA (7631-86-9)
Resp. Dust
Total Dust
Resp. Dust
Source
Manufacturer
UKOES
UKOES
ALUMINIUM OXIDE (1344-28-1 )
As Al.
Manufacturer
Total Dust
UKOES
Resp. Dust
UKOES
TWA
ppm mg/m
STEL
NOTE
ppm mg/m
0,1
6
3
10
10
5
UKMEL = UK Max. Exposure Limit UKOES = UK Occupational Exposure Standard
Note : Limits shown for guidance only. Follow applicable regulations.
Threshold limit value
9
5 mg/m suggested for nuisance dust.
Physical and chemical properties
Typical physical properties are given below. Consult product data sheet for specific details:
Physical state
Colour
Odour
pH
Boiling point C (F)
Melting point C (F)
Flash point C (F)
Flammability
Auto flammability
Explosive properties
Oxidizing properties
Vapour pressure - mmHg 20C
Vapour density
: Pellets
Some
: Odourless
: NA
: NA
: NE
: NA
: NA
: NA
: NA
: NA
: NA
: NA
SF4301EN/C
Product names :
Delsorb-HQ-SB-R
Delsorb-HQ-SB-WS
Physical and chemical properties (continued)
Evaporation rate
Relative density, 15/4C
Solubility in water
Partition coefficient
Viscosity at 40C, cSt
Viscosity at 100C, cSt
Pour point C
Freezing point C
NA = Not applicable
10
Page 4 of 5
: NA
: 2.1
: Negligible
: NE
: NA
: NA
: NA
NE
NE = Not established
D = Decomposes
Stability and reactivity
Stability (thermal, light etc.)
Conditions to avoid
Incompatibility (materials to avoid)
Hazardous decomposition products
Hazardous polymerisation
:
:
:
:
:
Stable
Extreme heat
Strong oxidisers and water
Silicon dioxide
Will not occur
Acute toxicity
Oral toxicity
Dermal toxicity
Inhalation toxicity
Eye irritation
:
:
Skin irritation
Practically non-toxic (LD50: greater than 2000 mg/kg)
Based on testing of similar products and/or the components.
Practically non-toxic (LD50: greater than 2000 mg/kg).
Based on testing of similar products and/or the components.
Not established
Practically non-irritating. (Draize score: greater than 6 but 15 or
less). Based on testing of similar products and/or the
components.
Practically non-irritating. (Primary Irritation Index: greater than
0,5 but less than 3). Based on testing of similar products and/or
the components.
11
12
Toxicological information
Ecological information
Environmental fate and effects
13
Not established
Product can be disposed of at an appropriate licensed waste
disposal site.
Disposal consideration
Waste disposal
SF4301EN/C
Product names :
14
Delsorb-HQ-SB-R
Delsorb-HQ-SB-WS
Transport information
USA DOT
RID/ADR
IMO
IATA
15
Page 5 of 5
:
:
:
:
Not regulated by USA Dot
Not regulated by RID/ADR.
Not regulated by IMO
Not regulated by IATA
EU labelling not required
Regulatory information
EU Labelling
The following product ingredients are cited on the lists below:
Chemical name
1=IARC 1
2=IARC 2A
3=IARC 2B
4=NTP CARC
5=NTP SUS
CAS number List citations
*** No reportable ingredients ***
-- Regulatory lists searched --6=NO ALLERGY
7=SE ALLERGY
8=SE CARC
9=DK CARC
10=DE TERAT A
11=DE TERAT B
12=DE TERAT C
13=DE TERAT D
14=DE CARC A1
15=DE CARD A2
16=DE CARC B
17=AT TERAT A
18=AT TERAT B
10=AT TERAT C
20=AT TERAT D
21=CH CARC
CARC = Carcinogen
SUS = Suspected carcinogen
TERAT = Teratogenic
AT
CH
DE
DK
NO
SE
16
= Austria
= Switzerland
= Germany
= Denmark
= Norway
= Sweden
Other information
New format
According to EU regulations (91/155/EEC)
SF4301EN/C
