Process-L4 SubProcess-L5 EquipmentType-L6
DISINFECTION (DIS) CONTACT TANK (CNT) VALVE (VAL)
TERTIARY TREATMENT (TTT) FILTERING (FIL) VALVE (VAL)
FINAL EFFLUENT DISCHARGE (FED) PUMPING (PMG) VALVE (VAL)
SLUDGE TREATMENT (SLT) SLUDGE DEWATERING (DEW) VALVE (VAL)
PRELIMINARY TREATMENT (PRT) GREASE AND GRIT REMOVAL (GGR) VALVE (VAL)
SECONDARY TREATMENT (SEC) CLARIFICATION/SETTLEMENT (CLA) PENSTOCK (PEN)
TERTIARY TREATMENT (TTT) BACKWASH SYSTEM (BWS) VALVE (VAL)
WHOLE SITE SERVICES (WHO) SERVICE WATER SYSTEM (SWS) PRESSURE MEASUREMENT (PSM)
INLET (INL) ODOUR CONTROL UNIT (OCU) PRESSURE MEASUREMENT (PSM)
WHOLE SITE SERVICES (WHO) SERVICE WATER SYSTEM (SWS) PUMP (PMP)
DISINFECTION (DIS) CHLORINE DOSING (CLD) WEIGHING SCALE (WSC)
SLUDGE TREATMENT (SLT) POLYMER DOSING UNIT (POL) MOTOR (MOT)
INLET (INL) CONTROL AND AUTOMATION SYSTEM (CAS) LOCAL CONTROL PANEL (LCP)
SECONDARY TREATMENT (SEC) CLARIFICATION/SETTLEMENT (CLA) MIXER (MXR)
TERTIARY TREATMENT (TTT) BACKWASH SYSTEM (BWS) MOTOR (MOT)
SECONDARY TREATMENT (SEC) CLARIFICATION/SETTLEMENT (CLA) MOTOR (MOT)
INLET (INL) PUMPING (PMG) VALVE (VAL)
SECONDARY TREATMENT (SEC) CLARIFICATION/SETTLEMENT (CLA) PENSTOCK (PEN)
INLET (INL) SCREENING (SCN) MOTOR (MOT)
DISINFECTION (DIS) CHLORINE DOSING (CLD) PRESSURE MEASUREMENT (PSM)
PRELIMINARY TREATMENT (PRT) GREASE AND GRIT REMOVAL (GGR) PUMP (PMP)
PRELIMINARY TREATMENT (PRT) GREASE AND GRIT REMOVAL (GGR) SCRAPER (SCA)
SECONDARY TREATMENT (SEC) AERATION (AER) STARTER (STR)
TERTIARY TREATMENT (TTT) CONTROL AND AUTOMATION SYSTEM (CAS) STARTER (STR)
SLUDGE TREATMENT (SLT) SLUDGE DEWATERING (DEW) PUMP (PMP)
SLUDGE TREATMENT (SLT) SLUDGE DEWATERING (DEW) PUMP (PMP)
TERTIARY TREATMENT (TTT) BACKWASH SYSTEM (BWS) PUMP (PMP)
TERTIARY TREATMENT (TTT) ODOUR CONTROL UNIT (OCU) VALVE (VAL)
DISINFECTION (DIS) CONTACT TANK (CNT) VALVE (VAL)
PRELIMINARY TREATMENT (PRT) GREASE AND GRIT REMOVAL (GGR) VALVE (VAL)
SLUDGE TREATMENT (SLT) POLYMER DOSING UNIT (POL) MOTOR (MOT)
INLET (INL) PUMPING (PMG) MOTOR (MOT)
TERTIARY TREATMENT (TTT) BACKWASH SYSTEM (BWS) MOTOR (MOT)
WHOLE SITE SERVICES (WHO) ODOUR CONTROL UNIT (OCU) MOTOR (MOT)
DISINFECTION (DIS) CHLORINE DOSING (CLD) VALVE (VAL)
TERTIARY TREATMENT (TTT) FILTERING (FIL) MOTOR (MOT)
SLUDGE TREATMENT (SLT) POLYMER DOSING UNIT (POL) PRESSURE MEASUREMENT (PSM)
WHOLE SITE SERVICES (WHO) ODOUR CONTROL UNIT (OCU) PUMP (PMP)
INLET (INL) SCREENING (SCN) CONVEYOR (CON)
SLUDGE TREATMENT (SLT) POLYMER DOSING UNIT (POL) PUMP (PMP)
SLUDGE TREATMENT (SLT) SLUDGE DEWATERING (DEW) PUMP (PMP)
INLET (INL) SCREENING (SCN) MOTOR (MOT)
SECONDARY TREATMENT (SEC) CLARIFICATION/SETTLEMENT (CLA) MOTOR (MOT)
PRELIMINARY TREATMENT (PRT) GREASE AND GRIT REMOVAL (GGR) MOTOR (MOT)
INLET (INL) SCREENING (SCN) MOTOR (MOT)
PRELIMINARY TREATMENT (PRT) GREASE AND GRIT REMOVAL (GGR) MOTOR (MOT)
WHOLE SITE SERVICES (WHO) SERVICE WATER SYSTEM (SWS) MOTOR (MOT)
SECONDARY TREATMENT (SEC) CLARIFICATION/SETTLEMENT (CLA) MOTOR (MOT)
WHOLE SITE SERVICES (WHO) SERVICE WATER SYSTEM (SWS) MOTOR (MOT)
SLUDGE TREATMENT (SLT) SLUDGE DRYING (DRY) MOTOR (MOT)
HIGH VOLTAGE SYSTEM (HVS) PANELS (PAN) CIRCUIT BREAKER (CBR)
HIGH VOLTAGE SYSTEM (HVS) PANELS (PAN) ELECTRICAL PANEL (PAN)
MOTOR CONTROL CENTRE (MCC) MCC PANELS (MCP) ELECTRICAL PANEL (PAN)
HIGH VOLTAGE SYSTEM (HVS) PANELS (PAN) INCOMER (INO)
SLUDGE TREATMENT (SLT) SLUDGE DRYING (DRY) EVAPORATOR (EVP)
HIGH VOLTAGE SYSTEM (HVS) TRANSFORMER GROUP (TRF) TRANSFORMER (TFR)
EquipmentDescription
VALVE (VAL) BUTTERFLY VALVE (BUV)
VALVE (VAL) BUTTERFLY VALVE (BUV)
VALVE (VAL) GATE VALVE (GAV)
VALVE (VAL) GATE VALVE (GAV)
VALVE (VAL)
PENSTOCK (PEN)
VALVE (VAL)
PRESSURE MEASUREMENT (PSM)
PRESSURE MEASUREMENT (PSM)
PUMP (PMP) CENTRIFUGAL PUMP (CFP)
WEIGHING SCALE (WSC)
MOTOR (MOT)
LOCAL CONTROL PANEL (LCP)
MIXER (MXR) STATIC
MOTOR (MOT)
MOTOR (MOT)
VALVE (VAL) NON RETURN VALVE (NRV)
PENSTOCK (PEN)
MOTOR (MOT)
PRESSURE MEASUREMENT (PSM)
PUMP (PMP)
SCRAPER (SCA)
STARTER (STR)
STARTER (STR)
PUMP (PMP)
PUMP (PMP)
PUMP (PMP) CENTRIFUGAL PUMP (CFP)
VALVE (VAL) BUTTERFLY VALVE (BUV)
VALVE (VAL) GATE VALVE (GAV)
VALVE (VAL)
MOTOR (MOT)
MOTOR (MOT)
MOTOR (MOT)
MOTOR (MOT)
VALVE (VAL)
MOTOR (MOT)
PRESSURE MEASUREMENT (PSM)
PUMP (PMP) CENTRIFUGAL PUMP (CFP)
CONVEYOR (CON) SCREW (SCO)
PUMP (PMP)
PUMP (PMP)
MOTOR (MOT)
MOTOR (MOT)
MOTOR (MOT)
MOTOR (MOT)
MOTOR (MOT)
MOTOR (MOT)
MOTOR (MOT)
MOTOR (MOT)
MOTOR (MOT)
ELECTRICAL PANEL (PAN) CIRCUIT BREAKER (CBR)
ELECTRICAL PANEL (PAN)
ELECTRICAL PANEL (PAN)
ELECTRICAL PANEL (PAN) INCOMER (INO)
EVAPORATOR (EVP) CHLORINE EVAPORATOR
TRANSFORMER (TFR)
Description
Ball Valve on Chlorine Mixture Pipeline of Chlorine Distribution Chamber
Butterfly Valve on Air Blower Pipeline of Sand Filter F
Gate Valve on Discharge Pipeline of Final Effluent Submersible Pump No. 1
Gate Valve on Suction Line of Thickened Sludge Pump No. 3
Penstock Valve Connected with Inlet Pipeline of Grease And Grit Removal Tank No. 1
Penstock Valve Number 12 of Distribution Chamber Clarification Tank Number 3 And 4 Old Stp
Pneumatic Cylinder for Backwash Inlet Sand Filter Bed No. 1
Pressure Gauge for Expansion Tank of Service Water
Pressure Gauge on Discharge Pipeline of Carbon Activated Tower
Service Pump No. 1 at Service Pumping Station
Weighing Scale of Chlorine Cylinders
Gearbox Connected With Motor of Polymer Dosing Screw Feeder Tank
Local Control Panel for Left Barscreen,Middle Barscreen,Right Barscreen,Conveyor
Mixer No. 1 Connected To Motor No. 1
Motor Connected With Back Wash Pump No. 2
Motor No. 2 Connected With Gearbox No. 2 Connected With Travelling Bridge
Non Return Valve on Discharge Pipeline of Submersible Pump No. 5
Penstock Valve No. 2 To Clarification Tank
Pneumatic Cylinder
Pressure Gauge Attached With Discharge Pipeline of Chlorine Water Booster Pump No. 1
Pump ( Under Ground Tank) for Discharge Pipeline of Grease And Grit Removal Tank No. 1
Scraper of Grease And Grit Removal Tank No. 1
Starter Panel for Aerator No. 1
Starter Panel for Pneumatic Penstock Valve & Gate Valve
Thickened Sludge Pump No 3 Connected With Motor
Wash Pump No. 1
Backwash Pump No 3 Feed Pump Building
Butterfly Valve of Discharge Pipeline of Air Blower No. 1
Gate Valve on Main Inlet for Both Contact Tank No. 1 & 2
Manual Penstock No. 1 Connected with Inlet of Grease And Grit Removal Tank
Mixer No. 1 Connected With Motor of Polymer Dosing Tank
Motor Connected To Raw Water Pump No. 4
Motor Connected With Backwash Pump No. 1
Motor Connected With Pump of Chlorine Gas Scrubber
Motorized Valve for Chlorine Cylinder
Pneumatic Cylinder Connected With Penstock Valve on Inlet Pipeline of Sand Filter No. 10
Pressure Gauge of Polymer Dosing Tank
Pump Connected With Motor of Chlorine Gas Scrubber
Screw Conveyor for Coarse Screening
Transfer Pump No. 1 Connected With Motor
Wash Pump No. 2
Air Compressor No. 1 for Pneumatic Fine Screen
Center Bearing for Travelling Bridge Clarification Tank No. 1
Gearbox Connected To Motor of Sand Classifier Screw Conveyor
Gearbox Motor Connected To Coarse Screen No. 1
Motor Connected To Screw Conveyor of Sand Classifier
Motor Connected with Centrifugal Pump Connected With Motor for Service Water at Inlet Boozer Area
Motor Connected With Gearbox Agitator Sludge Thickener
Motor Connected with Service Water Pump Connected With Motor for Service Water at Bypass Inlet Pumping Building
Scroll Compressor No. 4 Sludge Dryer Stage 2
Circuit Breaker for Floating Aerator
Lighting Panel for Sand Filter Building
Mcc Starter Panel for Sludge Recycle Pump No 1
Q1-Incomer- 2 From Generator
Evaporator No. 1 of Sludge Dryer Stage 1
Transformer No. 1 at Transformer Room
Manufacturer Name Model Number In Use Working Condition Capacity- DFF Capacity- UoM
NA NA YES YES GOOD 50 DN mm
BRAY NA YES YES GOOD 200 DN mm
NA NA YES YES POOR 250 DN mm
NA NA YES YES GOOD 65 DN mm
EMO NA YES YES GOOD 300 DN mm
NA NA YES YES POOR 200 DN mm
NA NA YES YES POOR 10 bar
WIKA NA YES YES POOR 5 bar
NA NA YES YES POOR 4 bar
NA NA YES YES GOOD 3500 RPM
NA 8D40k YES YES GOOD 4000 LSB
BONFIGLIOLI NA YES YES POOR 1500 RPM
NA NA YES YES POOR 230 V
NA NA YES YES GOOD 1775 RPM
NA NA YES YES CRITICAL 55 kW
NORD NA YES YES GOOD 0.37 kW
NA NA YES YES CRITICAL 800 DN mm
HAATO NA YES YES CRITICAL 600 DN mm
NA NA YES YES GOOD 10 bar
WIKA NA YES YES POOR 16 bar
NA NA YES YES GOOD 3 kW
NA NA YES YES GOOD 2 M
EATON NA YES YES POOR 240 V
NA NA YES YES POOR 10 bar
NETZSCH NA YES YES GOOD 4 m3/h
KSB NA YES YES GOOD 0.75 kW
KSB NA YES YES GOOD 360 m3/h
NA NA YES YES GOOD 150 DN mm
NA NA YES YES GOOD 150 DN mm
NA NA YES YES POOR 400 DN mm
NA NA YES YES GOOD 700 RPM
NA NA YES YES GOOD 4 kW
KSB NA YES YES GOOD 30 kW
NA NA YES YES GOOD 7.5 kW
NA NA YES YES GOOD 25 DN mm
NA NA YES YES POOR 100 mm/s
NA NA YES YES POOR 6 bar
NA NA YES YES GOOD 7.7 kW
NA NA YES YES GOOD 16 RPM
NA NA YES YES POOR 6 m3/h
KSB NA YES YES GOOD 2.29 m3/h
NA NA YES YES GOOD 9.1 bar
NA NA YES YES GOOD 1665 RPM
NA NA YES YES GOOD 56 RPM
NA NA YES YES GOOD 1745 RPM
NA NA YES YES GOOD 1.1 kW
NA NA YES YES GOOD 1.5 kW
NA NA YES YES GOOD 0.14 kW
NA NA YES YES GOOD 4 kW
NA NA YES YES GOOD 0.06 m3/h
NA NA YES YES GOOD 390 V
NA NA YES YES GOOD 240 V
NA NA YES YES GOOD 380 V
NA NA YES YES GOOD 380 V
NA NA YES YES GOOD NA NA
NA NA YES YES GOOD 750 V
Date of Manufacture Photo 1 Photo 2 Photo 3 Photo 4 Person
01/01/2018 PIC1 PIC2 PIC3 PIC4 Aneeq
01/01/2018 PIC1 PIC2 PIC3 PIC4 irma
01/01/2018 PIC1 PIC2 PIC3 PIC4 inam
01/01/2018 PIC1 PIC2 PIC3 PIC4 Raheel
01/01/2018 PIC1 PIC2 PIC3 PIC4 Ahmer Ansari
01/01/2018 PIC1 PIC2 PIC3 PIC4 Danish
01/01/2018 PIC1 PIC2 PIC3 PIC4 Aneeq
01/01/2018 PIC1 PIC2 PIC3 PIC4 irma
01/01/2018 PIC1 PIC2 PIC3 PIC4 inam
01/01/2018 PIC1 PIC2 PIC3 PIC4 Raheel
01/01/2018 PIC1 PIC2 PIC3 PIC4 Ahmer Ansari
01/01/2018 PIC1 PIC2 PIC3 PIC4 Danish
01/01/2018 PIC1 PIC2 PIC3 PIC4 Aneeq
01/01/2018 PIC1 PIC2 PIC3 PIC4 irma
01/01/2018 PIC1 PIC2 PIC3 PIC4 inam
01/01/2018 PIC1 PIC2 PIC3 PIC4 Raheel
01/01/2018 PIC1 PIC2 PIC3 PIC4 Ahmer Ansari
01/01/2018 PIC1 PIC2 PIC3 PIC4 Danish
01/01/2018 PIC1 PIC2 PIC3 PIC4 Aneeq
01/01/2018 PIC1 PIC2 PIC3 PIC4 irma
01/01/2018 PIC1 PIC2 PIC3 PIC4 inam
01/01/2018 PIC1 PIC2 PIC3 PIC4 Raheel
01/01/2018 PIC1 PIC2 PIC3 PIC4 Ahmer Ansari
01/01/2018 PIC1 PIC2 PIC3 PIC4 Danish
01/01/2018 PIC1 PIC2 PIC3 PIC4 Aneeq
01/01/2018 PIC1 PIC2 PIC3 PIC4 irma
01/01/2018 PIC1 PIC2 PIC3 PIC4 inam
01/01/2018 PIC1 PIC2 PIC3 PIC4 Raheel
01/01/2018 PIC1 PIC2 PIC3 PIC4 Ahmer Ansari
01/01/2018 PIC1 PIC2 PIC3 PIC4 Danish
01/01/2018 PIC1 PIC2 PIC3 PIC4 Aneeq
01/01/2018 PIC1 PIC2 PIC3 PIC4 irma
01/01/2018 PIC1 PIC2 PIC3 PIC4 inam
01/01/2018 PIC1 PIC2 PIC3 PIC4 Raheel
01/01/2018 PIC1 PIC2 PIC3 PIC4 Ahmer Ansari
01/01/2018 PIC1 PIC2 PIC3 PIC4 Danish
01/01/2018 PIC1 PIC2 PIC3 PIC4 Aneeq
01/01/2018 PIC1 PIC2 PIC3 PIC4 irma
01/01/2018 PIC1 PIC2 PIC3 PIC4 inam
01/01/2018 PIC1 PIC2 PIC3 PIC4 Raheel
01/01/2018 PIC1 PIC2 PIC3 PIC4 Ahmer Ansari
01/01/2018 PIC1 PIC2 PIC3 PIC4 Danish
01/01/2018 PIC1 PIC2 PIC3 PIC4 Aneeq
01/01/2018 PIC1 PIC2 PIC3 PIC4 irma
01/01/2018 PIC1 PIC2 PIC3 PIC4 inam
01/01/2018 PIC1 PIC2 PIC3 PIC4 Raheel
01/01/2018 PIC1 PIC2 PIC3 PIC4 Ahmer Ansari
01/01/2018 PIC1 PIC2 PIC3 PIC4 Danish
01/01/2018 PIC1 PIC2 PIC3 PIC4 Aneeq
01/01/2018 PIC1 PIC2 PIC3 PIC4 irma
01/01/2018 PIC1 PIC2 PIC3 PIC4 inam
01/01/2018 PIC1 PIC2 PIC3 PIC4 Raheel
01/01/2018 PIC1 PIC2 PIC3 PIC4 Ahmer Ansari
01/01/2018 PIC1 PIC2 PIC3 PIC4 Danish
01/01/2018 PIC1 PIC2 PIC3 PIC4 Owais
01/01/2018 PIC1 PIC2 PIC3 PIC4 Owais
