Presentation Highlighting Implication of NBC, Part-IV 2016

PRESENTATION HIGHLIGHTING IMPLICATION OF NBC-2016
PART IV
FIRE AND LIFE SAFETY
BUILDING SERVICE CONSULTANTS:
#93, Ananda Nilaya, Ittamadu,
KEB Main Road, BSK 3rd Stage, 3rd Phase
Bangalore – 560 085, Karnataka, India.
Reg Office.: #111, Upparahalli, Hoskote, Bangalore – 562 114.
Phone: +91 080 42182558 I info@colsonglobal.com | www.colsonglobal.com

SCOPE OF APPLICATION (OF NBC - 2016, PART-IV)

a) All high rise buildings (i.e., Buildings with height 15 m or above)
b) Special buildings, those are:
1) Hotel, educational, institutional, business, mercantile, industrial, storage, hazardous and mixed occupancies, where
any of these buildings have floor area more than 500 m2 on any one or more floors;
2) Educational buildings having height 9 m and above;
3) Institutional buildings having height 9 m and above;
4) All assembly buildings;
5) Building having area more than 300 m2 of incidental assembly occupancy on any floor; and
6) Buildings with 2 basements or more, or with one basement of area more than 500 m2.

COMMON IMPLICATIONS
(IRRESPECTIVE OF THE TYPE OF OCCUPANCY)

IMPLICATIONS ON STRUCTURE / ARCHITECTURAL PLAN
Fire Tower (Fire Fighting Shaft)
An enclosed shaft having protected area of 120 min fire resistance comprising - protected lobby, staircase and fireman's lift,
connected directly to exit discharge or through exit passageway with 120mm fire resistant wall at the level of exit discharge to
exit discharge.
•These shall also serve the purpose of exit requirement / strategy for the occupants
•The firefighting shaft shall be equipped with 120 min fire doors.
•The fire fighting shaft shall be equipped with firemen’s talk back, wet riser and landing valve in its lobby, to fight fire by fire
fighters.
NOTE:
1) Where such lobbies and staircase in the firefighting shaft are naturally ventilated / cross-ventilated, the shaft may not be
enclosed and fire door need not be provided.
2) For all enclosed firefighting shaft, the shaft’s lobby should have floor plan duly displayed for the information of fire fighters.

Fire Command Centre (FCC )
 Fire command centre shall be on the entrance floor of the building having direct access.
 The control room shall have the main fire alarm panel with communication system (suitable public address system) to aid
floors and facilities for receiving the message from different floors.
 Fire command centre shall be constructed with 120 min rating walls with a fire door and shall be provided with emergency
lighting.
 All controls and monitoring of fire alarm systems, pressurization systems, smoke management systems shall happen from
this room.
 Monitoring of integrated building management systems, CCTVs or any other critical parameters in building may also be
from the same room.
 Details of all floor plans along with the details of firefighting equipment and installations (2 sets laminated and bound)
shall be maintained in fire command centre.
 The fire staff in charge of the fire command centre shall be responsible for the maintenance of the various services and
firefighting equipment and installations in coordination with security, electrical and civil staff of the building.
Fire Resistance Ratings of Structural & Non-structural Elements
 Fire separation assemblies (like fire check doors) - 120 minutes for Type 1 construction
 Floor construction - 120 minutes for Type 1 construction

Staircase
 The number of risers shall be limited to 12 per flight.
 Internal stairs shall be constructed of non-combustible materials throughout, and shall have fire resistant rating of
minimum 120 min.
 Access to exit staircase shall be through a fire door of a minimum 120 min fire resistance rating.
 Scissor type staircase shall not be treated as part of exit.
Ramp
Slope of ramp shall not exceed 1 in 12 (8%)
Exit Requirements
All the exits and exit passageways to exit discharge shall have a clear ceiling height of at least 2.4 m. Height of exit door shall be
at least 2.0 m

Static Water Storage Tank
• Underground fire water storage tank(s) shall not be more than 7 m in depth
Fire Fighting Pump Room
• It is preferable to install the pump house at ground level. Pump house shall be situated so as to be directly accessible
from the surrounding ground level.
• Pump house shall be installed not lower than the second basement. When installed in the basement, staircase with direct
accessibility (or through enclosed passageway with 120 min fire rating) from the ground, shall be provided. Access to the
pump room shall not require to negotiate through other occupancies within the basement.
• Pump house shall be separated by fire walls all around and doors shall be protected by fire doors (120 min rating).
• Installation of negative suction arrangement and submersible pumps shall not be allowed.
• Pump house shall be installed not lower than the second basement
• No other utility equipment shall be installed inside fire pump room.
• Battery of diesel engine operated fire pump shall have separate charger from emergency power supply
• Fire pumps shall be provided with soft starter or variable frequency drive starter
• Sprinkler installation control valves, shall be installed inside fire pump room
Mixed occupancy
• Occupancies are required to be separated by a 240 min fire resistance rating
Basements
• In no case shall be less than two independent basement exits

Glazing
 For fully sprinklered buildings having fire separation of 9m or more, tempered glass in an non combustible assembly, with
ability to hold the glass in place, shall be provided.
 It shall be ensured that the sprinklers are located within 600mm of the glass façade providing full coverage to the glass.
 All gaps between floor-slabs and façade assembly shall be sealed at all levels by approved fire resistant sealant material of
equal fire rating as that of equal floor slab to prevent fire and smoke propagation from one floor to another
 Openable panels shall be provided on each floor and shall be spaced not more than 10 m apart apart measured along the wall
from center-to-center of the access openings. Such openings be operable at a height between 1.2 m and 1.5 m from the floor,
and shall be in the form of openable panels of size not less than 1000 mm x 1000 mm opening outwards.

TABLE 7 CHANGES
Business Buildings (E)
Residential Buildings (A)

Storage Buildings (H) – MLCP
Assembly Buildings (D)

TABLE 7 CHANGES
NOTES:
1) MOEFA system shall also include talk-back system and public address system for the occupancies given in table for (d) (1) (iii)
under A-5, (a) (2) under C-1, (a) (2) under D-1 to D-5, in all buildings 15m and above in height, except for A-3 and A-4
occupancies where these shall be provided for buildings of height 24m & above. These shall also be provided in car parking
areas more than 300 sqm & multi-level car parking irrespective of their area.
2) Automatic detection and alarm system is not required to be provided in car parking area. Such detection system shall however
be required in other areas of car parking such as electrical rooms, cabins and other areas
3) Sprinklers shall be fed water from both underground static water storage tank and terrace tank.
4) Lower levels in high rise buildings 60 m or above in height are likely to experience high pressure and therefore, it is
recommended to consider multi-outlet pumps (creating pressure zones) or variable frequency drive pumps or any other
equivalent arrangement
5) Pump capacity shall be based on covered area of the building
6) One set of pumps shall be provided for each 100 hydrants or part thereof, with maximum of two sets. In case of more than one
pump set installation, both pump sets shall be interconnected at their delivery headers
7) Alternative to provisions of additional set of pumps , the objective can be met providing additional diesel pump of same
capacity and doubling the water tank capacity as required for one set of pumps.

IMPLICATIONS ON FIRE / PHE SERVICE
Pump Capacity
As per latest NBC 2016, additional Jockey pump of capacity 180LPM is required (as standby)
Landing Valves
150mm main riser with Single outlet landing valves
Internal Hydrants
Internal Hydrants for firefighting and hose reels shall be located in the lobby in firefighting shaft. Those hydrants planned to be
provided near fire exit staircase on the floor shall be within 5 m from exit door in exit access.
Compartmentation
The maximum size of the compartments for basement car parking and offices shall be 3000 Sqm for sprinklered building.
Detection (Fire Alarm System)
Detectors shall also be provided inside the electrical shafts, and lift machine rooms, etc, besides occupancy areas.
Voice Evacuation System
Voice evacuation systems shall employ Hindi, English and vernacular language using pre- recorded messages and integrate with fire
alarm panels for alerting the zone of fire and surrounding zones/floors as required for annunciation.

 Electrical MV main distribution panel and lift panels shall be provided with CO2/inert gas flooding system for all panel
compartments with a cylinder located beside the panel.
 All transformers where capacity exceeds 10 MVA shall be protected by high velocity water spray systems or nitrogen injection
system
Passive Fire Protection
Automatic fire alarm system
Where automatic fire alarm system is provided, the following shall be monitored from fire alarm panel:
1) Water level in all tanks.
2) Hydrant and sprinkler pressures of respective zones as provided.
3) Pump ‘ON/OFF’ status.
4) All isolation valves, wherever provided with supervisory switch (non-padlock valves).
5) Other requirements to meet electro-mechanical services interface.
Emergency power for fire and life safety systems
Electrical MV main distribution panel and lift panels shall be provided with CO2/inert gas flooding system for all panel

IMPLICATIONS ON ELECTRICAL / HVAC SERVICE
• In general, it is desirable that the wiring and cabling are with flame retardant property. Medium and low voltage wiring
running in shafts, and within false ceiling shall run in metal conduit. Any 230 V wiring for lighting or other services, above false
ceiling, shall have 660 V grade insulation.
• The electric distribution cables/wiring shall be laid in a separate shaft. The shaft shall be sealed at every floor with fire stop
materials having the same fire resistance as that of the floor. High, medium and low voltage wiring running in shaft and in
false ceiling shall run in separate shaft/conduits.
• Water mains, gas pipes, telephone lines, intercom lines or any other service line shall not be laid in the duct for electrical
cables; use of bus ducts/solid rising mains instead of cables is preferred.
Emergency power supplying distribution system for critical requirement for functioning of fire and life safety system and
equipment shall be planned for efficient and reliable power and control supply to the following systems and equipment where
provided:
1) Fire pumps.
2) Pressurization and smoke venting; including its ancillary systems such as dampers and actuators.
3) Fireman’s lifts (including all lifts).
4) Exit signage lighting.
5) Emergency lighting.
6) Fire alarm system.
7) Public address (PA) system (relating to emergency voice evacuation and annunciation).
8) Magnetic door hold open devices.
9) Lighting in fire command centre and security room.

• Power supply to these systems and equipment shall be from normal and emergency (standby generator) power sources with
changeover facility.
• If power supply, is from HV source and HV generation, the transformer should be planned in standby capacity to ensure
continuity of power to such systems.
• Wherever transformers are installed at higher levels in buildings and backup DG sets are of higher voltage rating, then dual
redundant cables shall be taken to all transformers.
• The generator shall be capable of taking starting current of all the fire and life safety systems and equipment as above.
• Where parallel HV/LV supply from a separate substation fed from different grid is provided with appropriate transformer for
emergency, the provision of generator may be waived in consultation with the Authority.
Substation/Transformers
• Areas in substation shall not be used as storage/dump areas or for other utility purposes other than those required for the
functioning of the substation. The substation area should be adequately ventilated.
• An independent, ventilated or air conditioned MV panel room shall be provided on the ground level or first basement. This room
shall be provided with access from outside (or through exit passageway accessible from outside). The MV panel room shall be
provided with fire resistant walls and doors of fire resistance of not less than 120 min.
• If the licensees agree to provide meters on upper floors, the licensees’ cables shall be segregated from consumer cables by
providing a partition in the shaft. Meter rooms on upper floors shall not open into staircase enclosures and should be
ventilated directly to open air outside or in electrical room of 120 min fire resistant walls.

Oil filled substation
A substation or a switch-station with oil filled equipment shall be limited to be installed in utility building or in outdoor location.
Such substation/utility building shall be at least 7 m away from the adjoining building(s).
Substation equipment (exceeding oil capacity of 2000 litres) in utility building shall have fire rated baffle walls of 240 min rating
constructed between such equipment, raised to at least 600 mm above the height of the equipment (including height of oil
conservators) and exceeding 300 mm on each side of the equipment.
Lightning protection of buildings
Routing of down conductors (insulated or un-insulated) of lightning protection through electrical or other service shafts are
not allowed as it can create fire and explosion during lightning.
Lighting
a) The exit, exit access and exit discharge systems shall be illuminated continuously. The floors of the means of egress
shall be illuminated at all points, including angles and intersections, in corridors and passageways, stairwells, landings of
stairwells and exit.
b) Emergency lighting shall be powered from a source independent of that supplying the normal lighting.
c) Escape lighting shall be capable of:
1) indicating clearly and unambiguously the escape routes;
2) providing adequate illumination along such routes to allow safe movement of persons towards and through the
exits; and
3) ensuring that fire alarm call points & firefighting equipment provided along the escape routes can be readily located.

d) The horizontal luminance at floor level on the centre-line of an escape route shall not be less than 10 lumen/m2. In
addition, for escape routes up to 2 m wide, 50 percent of the route width shall be lit to a minimum of 5 lumen/m2.
In auditoriums, theatres, concert halls and such other places of assembly, the illumination of floor exit/access may be reduced
during period of performances to values not less than 2 lux.
e) Required illumination shall be arranged such that the failure of any single lighting unit, such as the burning out of one
luminaire, will not leave any area in darkness and does not impede the functioning of the system further.
f) The emergency lighting shall be provided to be put on within 5 s of the failure of the normal lighting supply. Also, emergency
lighting shall be able to maintain the required illumination level for a period of not less than 90 min in the event of failure of the
normal lighting even for smaller premises.
g) Battery pack emergency lighting, because of its limited duration and reliability, shall not be allowed to be used in lieu of diesel
engine driven emergency power supply.
h) Escape lighting luminaires should be sited to cover the following locations:
1) Near each intersection of corridors,
2) At exits and at each exit door,
3) Near each change of direction in the escape route,
4) Near each staircase so that each flight of stairs receives direct light,
5) Near any other change of floor level,
6) Outside each final exit and close to it,
7) Near each fire alarm call point,
8) Near firefighting equipment, and
9) To illuminate exit and safety signs as required by the enforcing authority.

Smoke Exhaust and Pressurization of Areas Above Ground
Smoke exhaust system having make-up air and exhaust air system shall also be required for theatres/auditoria.
Smoke exhaust system where provided, for above areas and occupancies shall have a minimum of 12 air changes per hour of
smoke exhaust mechanism.
For naturally cross-ventilated corridors or corridors with operable windows, such smoke exhaust system or pressurization system
will not be required.
Smoke Exhaust and Pressurization of Areas Below Ground
Mechanical ventilation system shall be designed to permit 12 air changes per hour in case of fire or distress call. However, for
normal operation, air changes schedule shall be as given in Part 8 ‘Building Services, Section 3 Air conditioning, Heating and
Mechanical Ventilation’ of the Code.
The smoke extraction system shall operate on actuation of flow switch actuation of sprinkler system. In addition, a local and/or
remote ‘manual start-stop control/switch’ shall be provided for operations by the fire fighters

IMPLICATIONS ON RESIDENTIAL BUILDINGS (GROUP A1 – A4)

Types of Construction
• Non-combustible materials should be used for construction of buildings, and the internal walls of staircase enclosures
should be of brick work or reinforced concrete or any other material of construction with minimum of 120 min rating.
• The walls for the chimney shall be of Type 1 or Type 2 Construction depending on whether the flue gas temperature is
above 200°C or less, respectively.
•Travel Distance – 30 m, for type 1 & type 2 construction
•Refuge Area (less than 60 m height) – Shall be provided for apartment buildings without balcony of height more than 24 m
and thereafter at every 15 m or so
a)Considering 0.3 m2 per person accommodating two consecutive floors and additional wheel chair space of 0.9 m2 for
every 200 occupants with minimum refuge area of 15 m2
b)High rise apartment buildings with apartments having balcony, need not be provided with refuge area
•Refuge Area (more than 60 m height) – Shall be provided for apartment buildings with balcony of height more than 60 m
and thereafter at every 30 m
a)Considering 0.3 m2 per person accommodating two consecutive floors , where occupant load shall be 12.5 m2 of gross floor
area and additional wheel chair space of 0.9 m2 for every 200 occupants with minimum refuge area of 15 m2
•Fire Protection
•For residential occupancies above 120 m in height, sprinklers shall be fed from the main and an alternate/standby riser with
suitable isolation valves
•Where height of building exceeds 150 m to 175 m, fire water static storage & pumps shall be required to be provided at 160 m
to 180 m
•Static water storage tanks located at such levels shall have half the storage of under ground static storage tank prescribed in
Table 7.
•Helipad- Buildings above 200 m in height
•Staircase - Height of risers - Residential buildings(A-2) - 190 mm (maximum height)
•Minimum staircase Width
a)Residential (A-2) :1 m
b)Residential (A-1, A-3 & A-4) :1.25 m

IMPLICATIONS ON HOTELS (GROUP A5 & A6)

Hotels (A-5)
a)All guest rooms and suites shall be protected by extended throw, quick response type sprinklers only. Also these areas shall be
provided with audio-based detectors having a sound level of at least 75 dB
Staircase - Height of risers - 150 mm (maximum height)
Minimum staircase Width
a)Residential Hotel (A-5 & A-6) : 1.50 m
Exit Requirements –
Dead end corridor length in exit access shall not exceed 15 m
Doorways – No exit doorway shall be less than 1000 mm in width

IMPLICATIONS ON ASSEMBLY BUILDINGS (GROUP D)

Life Safety
• Exit door width for assembly buildings shall not be less than 2 m
• Every place of assembly of sub-division D-1 shall have at least four separate exits as remote from each other
• Every place of assembly of sub-division D-2 shall have at least two separate exits as remote from each other and if of capacity
over 600, at least three exits shall be provided
•D-6 Occupancy
a) 50 percent lifts in common areas shall be with features and requirement of fireman’s lift
b) Manual call points shall be break glass and not pull stations
c) Photo luminescent markings shall be done along width and length of treads in all enclosed exits staircases. Exit directional
arrow on wall (in the direction of egress) shall be 175 mm x 50 mm
a) Refuge Area
To be provided on the floor at or immediately above 18 m shall not be less than 10 percent of gross area of floor. Next refuge
area to be at/on the floor immediately above 24 m which may be divided into 2 or more refuge areas with each being not less
than 100 m2
a) Assembly : 2 m
Exit Requirements
• Dead end corridor length in exit access shall not exceed 6 m
• Doorways – No exit doorway shall be less than 2000 mm in width.

IMPLICATIONS ON
EDUCATIONAL BUILDINGS (GROUP B) &
INSTITUTIONAL BUILDINGS (GROUP C)

EDUCATIONAL BUILDING (GROUP B)
• Every room with capacity of over 45 persons in area shall have at least two doorways
Note: Building, which will have only first floor and is accessible to not more than 20 pupils can have one exit not less than 900
mm wide
a) Educational : 1.5 m
Exit Requirements
• Common path of travel shall be 30 m

INSTITUTIONAL BUILDINGS (GROUP C)
Hospitals ( C-1)
a) All critical patients and those incapable of self-preservation and having physical impairment shall be housed within 30 m
height
b) Consultation rooms, nurses’ stations, medical shops , canteen etc may be housed at heights beyond 30 m but not more than
45 m
c) Basements shall not be used to store flammables or other laboratories particularly involving usage of chemicals
d) Any sleeping accommodation or suite exceeding 100 m2 in area shall have at least two doorways leading to exit access
corridors
e) Stretcher lift in a lift bank shall also act as fireman’s lift meeting requirements of Part 8
a) Institutional : 1.5 m
Exit Requirements

IMPLICATIONS ON BUSINESS BUILDINGS (TYPE E)

• Internal hydrants - Internal Hydrants for firefighting and hose reels shall be located in the lobby in firefighting shaft. Those
hydrants planned to be provided near fire exit staircase on the floor shall be within 5 m from exit door in exit access.
• Compartmentation- The maximum size of the compartments for basement car parking and offices shall be 3000 sqm for
sprinklered building.
• One firefighting shaft shall be planned for each compartment of business occupancy types.
• Electrical MV main distribution panel and lift panels shall be provided with CO2/inert gas flooding system for all panel
• Detectors shall also be provided inside the electrical shafts, and lift machine rooms, etc, besides occupancy areas.
• Voice evacuation systems shall employ Hindi, English and vernacular language using pre- recorded messages and integrate with
fire alarm panels for alerting the zone of fire and surrounding zones/floors as required for annunciation.
•Automatic Sprinkler Installation
•Automatic sprinklers shall be installed in false ceiling voids exceeding 800 mm in height
a) Business : 1.5 m
Exit Requirements
•Dead end corridor length in exit access shall not exceed 15 m
•Doorways – No exit doorway shall be less than 1000 mm in width.
•Not less than two exits shall be provided for every floor, including basements occupied for office purposes

Fire & Life Safety Audit
• Shall be carried out for all buildings having a height of more than 15 m
• Such audit shall preferably be conducted by a third party auditor having requisite experience
• Frequency of such audits shall be once in two years
Fire Officer
A qualified Fire Officer with experience of not less than 3 years shall be appointed who will be available on the premises,
for large educational complexes, business buildings with height 30 m and above, residential building with height 60 m and above,
institutional buildings of 15 m and above, starred hotels and D-6 occupancy.
Table 7 – Ready reckoner for minimum requirements of fire fighting installations
New Annexures :
•Annex F - Atrium
•Annex G – Commercial Kitchens
•Annex H – Car Parking Facilities
•Annex J - Fire And Life Safety Requirements For Metro Stations
•Annex M – Fire Protection Considerations For Venting In Industrial Buildings

ANNEX H - CAR PARKING FACILITIES
Vehicle ramps shall not be considered as exits unless pedestrian facilities are provided
H-3 Open Parking Structures (Including MLCP and Stilt Parking)
• Open parking structures are not required to be provided with Compartmentation
H-4 Enclosed Parking Structures
• All sprinklers in car parking shall be standard response type with minimum K-Factor of 80 area coverage of 9 m2
• For basement car parking, Compartmentation can be achieved, with fire barrier or with water curtain nozzle (K-23) .
Automatic deluge system comprising deluge valve, piping, nozzles, etc shall be used to zone the compartment in case of
water curtain system.
• In case of water curtain, existing water storage shall be supplemented by water demand for water curtain nozzles for 60 min
considering largest compartments perimeter out of all compartment of car parking in any of the basements
H-5 Automated Car Parking Structures Utilizing Mechanical or Computerized/Robotic Means
• Fire escape staircases, at least 1250 mm wide shall be provided at appropriate locations so that no place is more than 45 m
from the nearest staircase. Horizontal walkways, at least 1000 mm wide for access to all the areas shall be provided at every
parking level

As Per NBC 2005 As Per NBC 2016
Maximum number of occupants in a typical floor 569 Maximum number of occupants in a typical floor 569
Occupants per exit width as per table 21 50 Width per person, as per table 4 10
Total exit width units 11.38 Total exit width units 5690
Minimum capacity of exit stairway (mm) 500 Total number of stairways provided 4
Total width of stairway requiredin (mm) 5690 Width of each stairway (mtr) 1.423
Total number of stairways provided 4 Minimum capacity of exit stairway (mm) 1500
Width of each stairway (mtr) 1.4225
Staircase Width Calculation

Presentation Highlighting Implication of NBC, Part-IV 2016

Presentation Highlighting Implication of NBC, Part-IV 2016

More Related Content

What's hot (20)

Similar to Presentation Highlighting Implication of NBC, Part-IV 2016 (20)

Recently uploaded (20)

Presentation Highlighting Implication of NBC, Part-IV 2016